2004 Chevrolet Monte Carlo SS ACCESSORIES & EQUIPMENT Theft Deterrent

Download SCHEMATIC AND ROUTING DIAGRAMS THEFT DETERRENT SYSTEM SCHEMATICS Refer to System Wiring Diagrams . COMPONENT LOCATOR THEFT DETERRENT SYSTEM COMPONENT VIEWS Fig. 1: Passlock(tm) Sensor Connector, Left Center of Instrument Panel Courtesy of GENERAL MOTORS CORP. Callouts For Fig. 1 THEFT DETERRENT SYSTEM CONNECTOR END VIEWS Passlock Sensor Terminal Identification DIAGNOSTIC STARTING POINT – THEFT DETERRENT Begin the system diagnosis with Diagnostic System Check – Theft Deterrent . The Diagnostic System Check will provide the following information: * The identification of the control module(s) which command the system. * The ability of the control module(s) to communicate through the serial data circuit. * The identification of any stored diagnostic trouble codes (DTCs) and their status. The use of the Diagnostic System Check will identify the correct procedure for diagnosing the system and where the procedure is located. DIAGNOSTIC SYSTEM CHECK – THEFT DETERRENT Test Description The number(s) below refer to the step number(s) on the diagnostic table.… Read More

2001 Lexus GS 300 Reading Diagnostic Trouble Codes

Download NOTE: This is the only information provided by the manufacturer for reading diagnostic trouble codes for this system. If compressor lock occurs during A/C operation, the A/C switch indicator on the A/C control assembly starts blinking. When this occurs, check for compressor lock (DTC B1422) using diagnosis trouble code check then proceed to inspect the circuit or the component. Compressor lock sensor circuit. (See DTC B1422 Compressor Lock Sensor Circuit) By operating each of the A/C control switches as shown in the diagram, it is possible to enter the diagnosis check mode. a. Turn the ignition switch on while pressing the A/C control AUTO switch and R/F SW simultaneously. b. Check that all the indicators light up and go off at 1 second intervals 4 times in succession. a. Perform an indicator check. After the indicator check is completed, the system enters the DTC check mode automatically. b. Read the DTC displayed on the panel.… Read More

2007 Chevrolet Impala Transmission 1-2 Shift Shudder at Light to Moderate Acceleration

Download Models: 2001-2004 Buick Regal 2001-2005 Buick Century, LeSabre 2002-2007 Buick Rendezvous 2005-2007 Buick Terraza, LaCrosse, Allure (Canada Only) 2006-2007 Buick Lucerne 2001-2005 Chevrolet Venture 2001-2007 Chevrolet Impala, Monte Carlo 2005-2007 Chevrolet Uplander 2006-2007 Chevrolet Malibu SS, Malibu Maxx SS 2001-2002 Oldsmobile Intrigue 2001-2003 Oldsmobile Aurora 2001-2004 Oldsmobile Silhouette 2001-2005 Pontiac Aztek, Bonneville, Montana 2001-2007 Pontiac Grand Prix 2005-2007 Pontiac Montana SV6 2006-2007 Pontiac G6 GTP 2005-2007 Saturn Relay with 4T65E Automatic Transmission (RPOs MN3, MN7, M15, M76) Supercede: This bulletin is being revised to update parts information. Please discard Corporate Bulletin Number 06-07-30-023B (Section 07 – Transmission/Transaxle) . Condition Some customers may comment on a 1-2 shift shudder at light to moderate acceleration. Typically, the throttle plate angle parameter is 12-20% at time of condition with vehicle speed of approximately 24-40 km/h (15-25 mph). The customer may describe the condition as slip or delayed shift into second. Correction Replace the complete second clutch assembly with service kit, P/N 24240561.… Read More

2003 BMW 325I Sport Wagon Check engine light on and fault codes stored

Download 2002 BMW 325I 2.5L 2003 BMW 325I Sport Wagon 2.5L, Eng Des M54, USA Customer Concern: Check engine light on and fault codes stored. Vehicle running normally. Tests/Procedures: 1. Based upon stored fault codes for secondary air system, there is little or no flow of secondary air into engine. Typical causes for this issue are failed secondary air pumps and/or secondary air check valves. Secondary air pump should operate under normal circumstances when vehicle is first started to perform system test. Pump will normally be heard running when standing in front right corner of vehicle. 2. The secondary air pump is located in the right front of engine compartment. A secondary air pump relay located in the glove box is controlled by the engine control module and sends power to the secondary air pump. 3. Air pump can be disconnected and supplied with power and ground at pump to verify operation is possible.… Read More

2003-2005 Ford Excursion DIESEL CALIBRATION UPDATE

Download 6.0L DIESEL CALIBRATION UPDATE—VARIOUS ISSUES 2003-2007 F-Super Duty FORD: 2004-2010 E-Series 2003-2005 Excursion This article supersedes TSB 9-7-11 to update the The PCM and FICM calibration update contains model years covered and Integrated Diagnostic improvement actions to address the following System (IDS) calibration level. symptoms: 2005 F-Super Duty 6.0L: ISSUE Some 2003-2007 F-Super Duty vehicles, 2003-2005 •False DTC P0470 – Exhaust pressure sensor A Excursions and 2004-2010 E-Series vehicles, circuit fault due to a freezing condition. equipped with a 6.0L diesel engine may exhibit hard •False DTC P0404 – Exhaust gas recirculation start, no start, white smoke, lack of power, running (EGR) performance due to a stuck turbocharger rough condition after cold engine start up, or condition. diagnostic trouble codes (DTCs) P0404, P0470, •Cooling loss protection – Revised engine P0611, P1260 and/or P1378 issues. Refer to the protection strategy when an engine Calibration Content for information detailing specific over-temperature condition is present.… Read More

INSTALLATION INSTRUCTIONS FOR PART 99-5812

DOWNLOAD APPLICATIONS FORD Edge 2007-2010 / Expedition 2007-2010 Explorer 2006-2010 / Explorer Sport Trac 2006-2010 F-150 2004-2008 / E Series 2009-10 / F Series 2005-2009 Five-Hundred 2005-2007 / Focus 2005-2007 / FreeStar 2004-2007 Freestyle 2005-2007 / Fusion 2006-2011 Mustang 2005-2009 / Super Duty 2008-2011 Taurus 2008 / Taurus X 2008-2009 MERCURY Monterey 2004-2007 / Milan 2006-2008 Montego 2005-2007 / Mountaineer 2006-2010 Sable 2008-2009 LINCOLN Mark LT 2005-2008. WIRING AND ANTENNA CONNECTIONS (Sold Separately) Harness: • 70-5520 – Ford Harness 2003-up • 70-5521 – Ford Amplified Harness 2003-up • 70-5522 – Ford Sub Harness 2003-up • XSVI-5520 NAV – Ford Interface 2006-up Antenna Adapter: • 40-CR10 – Chrysler/GM Antenna Adapter 2002-up. DASH DISASSEMBLY FORD F-150 2004-2008 LINCOLN MARK LT 2005-2008 FORD EXPEDITION 2007-2010 FORD EDGE 2007-2010. 1 Disconnect the negative battery terminal to prevent an accidental short circuit. Unsnap and remove entire panel surrounding the radio and climate controls. (Figure A) Remove (4) 9/32″ screws to remove the factory radio.… Read More

2004-2006 Ford Double DIN Installation Kit PART 95-5812 INSTALLATION INSTRUCTIONS

Download FORD Edge 2007-2009 / Expedition 2007-2009 Explorer 2006-2009 / Explorer Sport Trac 2006-2009 F-150 2004-2008 / F Series 2005-2008 Five-Hundred 2005-2007 / Focus 2005-2007 / FreeStar 2004-2007 Freestyle 2005-2007 / Fusion 2006-2009 Mustang 2005-2009 / Super Duty 2008-2009 Taurus 2008-2009 / Taurus X 2008-2009 MERCURY Monterey 2004-2007 / Milan 2006-2008 Montego 2005-2007 / Mountaineer 2006-2009 Sable 2008-2009 LINCOLN Mark LT 2005-2009 Factory Navigation Only: MKX 2007-2009 / Navigator 2007-2009. DASH DISASSEMBLY A B C D E FORD MUSTANG 2005-2009 Remove the small rectangular shifter lever trim panel if equipped . (Figure A) 2 Remove (4) 9/32″screws from the radio to remove. (Figure E) 7 Remove (2) Phillips screws from under the center armrest at the back of the shifter trim panel (includingcup holders). (Figure B) 3 Unclip and remove panel. (Figure B) 4 Unclip and remove the (2) center stack trim panels from the left and right side of the radio and climate controls.… Read More

1995-1997 FORD EXPLORER TRANSFER CASE BINDING OR SHUDDER DIAGNOSTICS

Download FORD: 1995-1997 EXPLORER 2. Connect the New Generation Star (NGS) Tester ISSUE to the Data Link Connector (DLC) underneath The diagnostic procedure for binding or shudder the steering wheel. Monitor for any Diagnostic from transfer case in slow, tight turns while in 4 Trouble Codes (DTCs) set by the transfer case Auto mode may be inaccurate for some vehicles. that could indicate incorrect speed sensor function. Codes could include, but are not ACTION limited to: Diagnose transfer case binding or shudder concerns using the following Diagnostic Procedure. •P1836 – Front propshaft sensor circuit failure •P1837 – Rear propshaft sensor circuit failure DIAGNOSTIC PROCEDURE •P1874 – Hall effect sensor power short circuit to battery 1997 EXPLORER •P1875 – Hall effect sensor power circuit 1. Test drive the vehicle in 4 Auto, 4 High and 4 failure Low. Evaluate the vehicle in each of these NOTE modes. The vehicle should bind in turns in both ADDITIONAL CODES COULD BE SET AS WELL.… Read More

2003 – 2007 FORD 6.0L Power Stroke Installation Instructions

Download This is a high performance product and we suggest that you also install Exhaust Gas Temperature (EGT) and boost gauges with all Quadzilla products. This product may alter the technician’s ability to use diagnostic equipment Please remove the Quadzilla product when taking your truck into a service facility. Installation To begin the installation of your new Adrenaline module, first make sure the ignition is turned to the off position and the key is removed from the ignition. When routing wires pay special attention to avoid any moving, sharp, or hot engine compo- nents First open the hood and lay out the main wiring harness. The following leads will go to their respec- tive locations. Begin by installing the thermocouple probe into the exhaust manifold. The best location to install the thermocouple is on the very back of the manifold in the bend. This will have to be done from underneath the vehicle.… Read More